as i drive more and more on my 1.9, it may be getting tired
and a rebuild my be in question, since it just started getting a leak
couple inches from my drain bolt, sure i have a leaky head on the right
side, but tring to get the most out of this motor/without wrecking it.

--
Joseph  Fortino
fortino1@onebox.com - email
(510) 360 -7829 voicemail/fax

----         Jere Hawn <jbrschawn@EARTHLINK.NET> wrote:
> That single drip will grow,.  It's a fairly easy one to change if you
> change
> your oil at the same time.
>
>                 1. Drain oil
>                 2. Remove oil filter
>                 3. Remove threaded pipe that holds filter on, should
> be about hand tight
> after you loosen the retaining nut
>                 4. Oil cooler will drop right off
>                 5. Replace little hose that goes into cooler (I suspect
> the leak is there
> or at o-ring)
>                 6. If you still have the original O-ring behind cooler
> REPLACE IT! I think
> there is a newer mode to it but not sure if it applies to an 85'
>                 7. Replace cooler w/ new o-ring and pipe with nut
>                 8. Put new oil filter on and refill engine with 4.7
> qts. (approx) of oil
> (I prefer Castrol 20-50)
>                 9. You'll probably have to top off the coolant and
> bleed the system
> depending on how much you loose during the process
>
>          Total time: .75 hrs my time or 2.5 weeks mechanic time @ $60/hr.
> :)
>
>         Good luck,
>
> Jere
> 90 GL
> 88 GL
>
>         =================
>
>
>
> On Wed, 22 Aug 2001 14:02:33 -0500 Kim G <ppg1@HOTMAIL.COM> writes:
>  Hi List,
>  I read a post yesterday about a single drip of coolant off the end
> of the
> oil filter....and a hidden S-pipe.  Sometimes, my van leaves a
> single drip, and it comes right off the bottom of the oil filter, and
> it
> seems to be coming from a bolt that holds the water pump on, a little
> bit
> above the filter.  But anyways, where should I look for this s-pipe
> and it
> my single drip going to be a problem?  It has been having one single
> drip
> every now and then since last summer, but I would like to fix it if
> I can
> find the cause.  Also, I do not have any trouble with overheating,
> or with
> the coolant level, and my van is working  treat, except for marking
> it's
> territory sometimes.  thanks for any info,
> Kim
> 85 GL
>

__________________________________________________
FREE voicemail, email, and fax...all in one place.
Sign Up Now! http://www.onebox.com