Skip to main content
Gerry | Vanagon
Checking account...
← vanagon.com home · Continue the discussion in the forum
Subject:Re: head lamp relay upgrade
From:Frank Condelli
Date:Mon, 29 Mar 2004 06:29:52 EST

In a message dated 28/03/2004 10:54:26 PM Eastern Standard Time,
LISTSERV@GERRY.VANAGON.COM writes:

Ok Bob,  you did yours wrong also. That explains why you are burning up
headlight  switches now that you have added more lights. Frank needs to
make the  installation instructions clearer I guess. The correct wires
are inside a  black plastic sleeve in the area nearest the dimmer switch.
That makes it  less obvious which wires to use though I don't understand
why 2 guys would  think it ok to splice into wires that are clearly the
wrong colors and way  too small to be the headlight wires.

Mark, thank you.  Since I'm not a technical  writer my directions may have
some ambiguity to some readers.  BUT, like  Marks says, I clearly state that the
wires that need to be accessed are 12 gauge  white and yellow wires.  If you
cut into other wires then that's your  error.  The only reason I say to remove
the lower steering wheel cover is  so that when trying to locate the wires
near the fuse/relay panel where the  cut should be made, is so that you can
trace the ends to the dimmer switch to  insure you've found the proper wires
BEFORE cutting and making  a mistake.  There is absolutely no need to cut the black
casing of  these wires up near the switch as this is not the proper location
for the splice  to have enough wire left to reach the relays.  Read my
directions  carefully, copied below..........
<<Remove the plastic cover from the underside of the steering column,  two
screws and spring clipped in place, to expose the wiring to the turn
signal/dimmer switch. Locate the 12 ga. white and yellow wires leading to the  switch.
Follow these two wires back to the fuse block. Cut these two wires so  that the
four resulting wire ends will reach the relay sockets.>>
Cheers,

Frank  Condelli
Almonte, Ontario, Canada
_BusFusion_ (http://members.aol.com/BusFusion/bfhome.htm)  a VW Camper
camping event, Almonte, ON, June 10 ~ 13, 2004
'87 Westy & Lionel  Trains
Member: _Vanagon List_ (http://www.vanagon.com/) , _LiMBO_
(http://www.bcn.net/~limbo/) , _IWCCC_ (http://www.westfalia.qc.ca/)  & _CCVWC_
(http://www.ccvwc.ca/)
Vanagon/Vanagon Westfalia Service in  the Ottawa Valley
_STEBRO/Vanagon Stainless Steel  Mufflers_
(http://members.aol.com/Fkc43/stebro.htm)
_Frank Condelli &  Associates_ (http://members.aol.com/Fkc43/busindex.html)
or  http://frankcondelli.com