Thanks all.   The TPS clicks correctly, but maybe it's faulty..the fuel
pressure regulator...hmm, I have no other indications of fuel problems
except when I coast, and only sometimes...all other running conditions,
everything is perfect..
Idle, full throttle, up and down, pump the gas... can't get any fueling
misbehaving anywhere.
   I think I will swap the fuel pump relay and the ECU...first.
   Thanks again...

On Thu, Sep 13, 2018, 2:40 PM Michael Kubler <michael@kublers.com> wrote:

> What about fuel filter?   Just grasping at straws here.
>
> Mike
> 971-322-7145
>
> On Sep 12, 2018, at 19:00, Don Hanson <dhanson928@gmail.com> wrote:
>
> 84 vanagon, digifant, inline ABA Jetta motor....I've recently replaced the
> fuel pump and filter and the sparkplugs.  Lubed the throttle linkage with
> light spray lube.   All was normal "reading" with the spark plugs.  I
> replaced the fuel pump after the old one failed (not so sure now) as I
> recall a sustained downhill just prior to the pump failure...However, I put
> on my spare and all was good, then replaced that with a new Bosch and still
> all good.   The motor sounds perfect, has plenty of power, no smoking or
> missing....smoooth running and sweet sounding, as always.  Same fuel
> economy....
>     But I was feeling an occasional hesitation after a sustained downhill
> with no throttle, have been feeling that occasionally, but not serious,
> till it stopped recently and I swapped the fuel pump on the road, then
> replaced the spare.   I've put a few hundred miles on since that, with no
> signs of what happened tonight, twice.
>
>    Coastng downhill (about 6% grade) for perhaps a mile with no throttle
> at all, then step back on the gas and nothing....No warning lights, normal
> gauges temp and oil temp...just no motor...So I cycle the on off ignition
> and get a few seconds of power than sputter and dies...still coasting
> downhill...cycle again with the key and I get another burst of power, then
> off...repeat, than it clears up and continues on, but I am careful to leave
> some throttle on and no more weirdness...till I encounter another 3000"
> descent...Same deal...coast for a mile or so without any gas on and when I
> step back into it, nothing!   Another 4 or 5 off and on with the key and it
> again clears up and runs normal.....No smoke or anything,
> Feels sort of like the fuel is shut off,,,but only after I coast downhill
> for a mile or two with the throttle shut....Uphill at 4000 or 5000 rpm and
> full throttle, its smooth and happy....going through the mountains in all 5
> gears like Dan Gurney, its sweet....if I keep a bit of throttle on going
> downhill, it seems to behave, but let completely off and it sometimes just
> quits, till I cycle the ignition and get it back (so far that works)
>   Anybody have any ideas?   I am thinking throttle stop switch or maybe
> fuel pump relay...or maybe ignition switch....Help?
>    Don Hanson
>
> --
> You received this message because you are subscribed to the Google Groups
> "Vanagons, VW Buses (Bays) With VW/Audi, Inline or VR Gas Engines" group.
> To unsubscribe from this group and stop receiving emails from it, send an
> email to
> vanagons-with-vw-inline-4-cylinder-gas-engines+unsubscribe@googlegroups.com
> .
> To post to this group, send email to
> vanagons-with-vw-inline-4-cylinder-gas-engines@googlegroups.com.
> To view this discussion on the web visit
> https://groups.google.com/d/msgid/vanagons-with-vw-inline-4-cylinder-gas-engines/CAHTkEuKBDkjdo3JrZxo4AdwPO09UqZA1_KXzjVUu_-dsYK6heA%40mail.gmail.com
> <https://groups.google.com/d/msgid/vanagons-with-vw-inline-4-cylinder-gas-engines/CAHTkEuKBDkjdo3JrZxo4AdwPO09UqZA1_KXzjVUu_-dsYK6heA%40mail.gmail.com?utm_medium=email&utm_source=footer>
> .
> For more options, visit https://groups.google.com/d/optout.
>
> --
> You received this message because you are subscribed to the Google Groups
> "Vanagons, VW Buses (Bays) With VW/Audi, Inline or VR Gas Engines" group.
> To unsubscribe from this group and stop receiving emails from it, send an
> email to
> vanagons-with-vw-inline-4-cylinder-gas-engines+unsubscribe@googlegroups.com
> .
> To post to this group, send email to
> vanagons-with-vw-inline-4-cylinder-gas-engines@googlegroups.com.
> To view this discussion on the web visit
> https://groups.google.com/d/msgid/vanagons-with-vw-inline-4-cylinder-gas-engines/FC4600FC-14EB-4196-A15B-11059B70C291%40kublers.com
> <https://groups.google.com/d/msgid/vanagons-with-vw-inline-4-cylinder-gas-engines/FC4600FC-14EB-4196-A15B-11059B70C291%40kublers.com?utm_medium=email&utm_source=footer>
> .
> For more options, visit https://groups.google.com/d/optout.
>